Collingdale, PA

Performed tune up on Goodman gas furnace, ran unit in heating mode and tested combustion and gas pressure as well as checked heat exchanger and temperature split. Flame sensor was checked and cleaned and all associated ignition components were checked, blower motor and inducer motor were checked and drain was cleaned, no issues with unit at this time.

Replacement of water heater. Customer is moving forward with the DiBiase in-house payment plan; authorized by Management. Customer will provide $1,014.90 deposit and the remainder balance will be equally paid within the next four months.

Changed filter, tested condensate safeties, checked electrical, checked delta t, inspected coils, checked capacitor, checked pressures. System is in normal operation at this time.

Performed ac tune up on 2014 Goodman 1.5 ton unit. Check electrical low and high voltage connections and components. Filter ok check supply and return air. 66/50 total split 16 degrees. Check indoor coil. Indoor coil is in bad shape (dirty). Took photos of coil condition. To clean coil we will have removed coil and take it outside to clean. Check outdoor unit capacitor and contactor. Used water to hose off coil, pressures seem to be slightly lower than normal. As right now It’s not affecting the performance of the unit, but it could be in near future, inform customer about coil condition. Unit is from 2014. During todays visit noticed water heater is leaking. Took photos and video. Provided an estimate to replace water heater.

Reviewed equipment and found outdoor unit capacitor looked clean and measured proper capacitance. Contactor slightly worn but replacement not required at this time. Found outdoor unit not starting due to no low voltage present to contactor. Inspected furnace and found 6 flash code indicating open rollout. Tested all rollouts and checked air filter. Found no low voltage at R and C on board. Found fuse blown. Inspected thermostat and found common wire (blue) landing on Rc terminal. This caused short and fuse to blow. Removed from Rc terminal (no provisions for comon on thermostat). Replaced fuse and tested ac operation. Unit outdoor coil is dirty and recommend annual service on system.

Performed gas furnace tune up. Replaced air filter, performed combustion analysis, checked gas pressure lowering manifold side, tightened all wiring, checked amp draw. System is working as it should at this time. Cycle heater couple times ok provided information about air purification system.